Shenzhen Hanast New Material co.,LTD
উদ্ধৃতি
বাড়ি >
ব্লগ
> কোম্পানির ব্লগ সম্পর্কে Platinum Cure Silicone Rubber for Concrete & Building Mold Making: 2026 Spec, Hardness & Cost Guide

Platinum Cure Silicone Rubber for Concrete & Building Mold Making: 2026 Spec, Hardness & Cost Guide

2026-11-06

সম্পর্কে সর্বশেষ কোম্পানি খবর Platinum Cure Silicone Rubber for Concrete & Building Mold Making: 2026 Spec, Hardness & Cost Guide
Quick Answer

Platinum cure (addition cure) RTV-2 silicone is the standard mold material for concrete, gypsum and building-product casting because it shrinks less than 0.1%, releases cleanly from cement slurry and reproduces stone texture down to fine grain. For most building molds, use Shore A 20–35, mix viscosity 8,000–20,000 cps, 1:1 mix ratio by weight, 3–4 hours cure at 25 °C, and expect 50–200+ demolding cycles per mold depending on abrasive load.

Why Platinum Cure Silicone Beats Tin Cure for Building Molds

Building molds are abused: abrasive cement, alkaline slurry, heavy stone blanks dropped in and out every cycle. Three properties decide whether a mold survives 30 cycles or 300.

  • Shrinkage: addition cure 0.1% or less vs 0.3–0.6% for tin cure (condensation cure). On a 600 mm culture stone mold that difference is 2–4 mm of drift — enough to lose the interlocking tolerance between panels.
  • No by-product: tin cure releases alcohol during cure, which leaves a film that transfers to the first casts. Platinum cure has no by-product, so the first pull is already clean.
  • Tear and tensile strength: platinum cure typically delivers 25–40 kN/m tear strength, which is what keeps thin undercut edges on brick-face and wood-grain textures alive.

The trade-off is inhibition sensitivity: sulfur, amine-cured epoxy, certain clays and latex gloves will stop platinum silicone from curing. Sections 6 and 7 cover the fix.

Specification Table
ParameterTypical rangeWhat it means for a building mold
HardnessShore A 0–50 (mold work: 20–35)Lower = easier demolding of deep texture; higher = better dimensional hold on flat panels
Mix viscosity800–20,000 cpsLow viscosity (800–3,000 cps) de-airs itself into fine stone grain; high viscosity stays on vertical surfaces
Mix ratio1:1 by weightForgiving on the shop floor; no scale drift from 10:1 dispensing errors
Pot life20–60 min at 25 °C30 min covers a typical 5–20 kg pour
Cure time3–4 h at 25 °C (demold)Full mechanical properties at 24 h
Linear shrinkage≤ 0.1%Keeps multi-panel tile systems dimensionally matched
Tear strength25–40 kN/mSurvival of thin texture edges and undercuts
Service temperature−40 °C to +200 °CSafe for exothermic gypsum and cement cure
Hardness Selection by Mold Type
Mold / productRecommended Shore AReason
Culture stone (split-face, deep relief)25–35Deep undercuts need elongation to strip without tearing
Wall tile, thin brick veneer20–30Fine surface grain plus repeated flexing for release
Architectural panel, large flat fascia30–40Holds flatness over 1 m+ spans
Master pattern / replica of original stone10–20Maximum detail pick-up from the positive
Concrete baluster, cornice, capital30–40Abrasion resistance on high-cycle production
Six-Step Process for a Reliable Concrete Mold
  1. Seal the master. Concrete, gypsum and wood positives are porous. Apply a sealer, then a release agent. Unsealed gypsum will absorb silicone and produce a chalky, short-lived mold.
  2. Check for inhibitors. Sulfur-based clay, tin-cure residue, amine epoxy, some 3D-print resins and latex gloves block platinum cure. Test a 50 g cup pour for 4 hours before committing a full batch.
  3. Weigh 1:1 by weight. Part A is pigment-filled and Part B is the catalyst — volume mixing drifts the ratio and leaves tacky spots.
  4. Degas. Vacuum to 1–3 mbar for 2–3 minutes. Air bubbles at the texture face become pinholes in every cast.
  5. Pour in a thin stream from one corner so air is pushed ahead of the flow, not trapped under it. For vertical faces, use thixotropic or high-viscosity grade.
  6. Demold at 3–4 h, use at 24 h. Early demolding is fine for a thin skin mold but full tear strength needs a full day.
How to Calculate Silicone Consumption and Cost per Mold

Volume of silicone (cm³) = mold length * width * average wall thickness (typically 5–10 mm for backed molds, 15–25 mm for free-standing block molds). Mass (g) = volume * 1.1–1.2 g/cm³.

Worked example: a 500 * 300 * 20 mm block mold = 3,000 cm³ ≈ 3.3–3.6 kg of silicone. At 150 demolding cycles per mold and 4 casts per hour, silicone cost per cast usually lands between USD 0.15 and USD 0.45 — which is why the hardness and tear-strength choice matters more than the raw material price.

FAQ Can I use platinum cure silicone for cement directly?

Yes. Cured platinum silicone is chemically inert to cement slurry and gypsum. The limiting factor is abrasion and the alkalinity of the mix, not chemical attack. Expect 30–80 cycles for high-abrasion dry-cast concrete, 150–300 cycles for gypsum decorative work.

Why did my platinum silicone stay sticky?

Inhibition, in this order of likelihood: sulfur or latex contamination, amine-cured epoxy or 3D-print resin master, wrong mix ratio, or workshop below 15 °C. Warm the material to 25 °C and re-test on a clean cup sample.

Tin cure or platinum cure for a first mold?

Platinum, unless the master contains sulfur clay or tin residue. Platinum gives a longer service life and a cleaner first cast; tin cure remains useful for polyester and resin casting where platinum is inhibited.

How many molds can I get from one 20 kg kit?

At an average 3.5 kg per 500 * 300 mm block mold, a 20 kg kit yields roughly 5–6 molds.

Can silicone molds be repaired?

Yes — clean with isopropyl alcohol, roughen the area, and patch with fresh 1:1 silicone. Repaired molds typically retain 70–90% of original cycle life at the patch.

Next Step

Hanast has manufactured RTV-2 platinum cure silicone since 2010 at its 40,000 m² plant in Shenzhen, exporting 70–80% of output to industrial mold makers. Grades cover Shore A 0–50 and mix viscosity 800–20,000 cps, with 3–4 hour cure and free samples for mold trials. Send your mold dimensions, texture depth and substrate (concrete / gypsum / resin) and we will return a hardness and viscosity recommendation with a per-mold consumption calculation.